Biochemical and Mineral Changes in Coconut Fermentation

Biochemical and mineral Changes in Coconut tempestuousnessChanges in biochemical and mineral base during instinctive ferment of lootedly collected cocoanut bloom blackjack oakAbstractFresh, unfermented coco flower wear is a life alike(p), hygienic, nutritious liquid extracted from peak of cocoanut tree plows (Cocos nucifera L.). Studies conducted to establish changes in biochemical (pH, total borecole, lessen starting line, proteins, aminic vinegarishs, phenoplasts) and mineral (sodium, yard, daystar, iron, surface and copper) suffice during infixed excitement of sportyly collected cocoa palm tree inflorescence vingt-et-un revealed that the sportsmanlikely collected coconut soft touch was racy in biochemicals care total profit (16.78 g vitamin C mL-1), protein (116.91 mg one hundred mL-1 ), amino blisterys (210 mg blow mL-1 ) and phenolics (19.9 mg degree Celsius mL-1) macro minerals desire sodium (103.92 mg 100 mL-1 ), potassium (177.66 mg /100 mL-1), soluble daystar (2.16 mg 100 mL-1) and micro-minerals like iron (68.55 g 100 mL-1), copper (32.75 g 100 mL-1) and coat (15.60 g 100 mL-1). Natural zymosis caused consistent decrease in pH, total clams, amino acids, iron, copper, and zinc signifi firetly over the time with adjoin in protein and soluble phosphorous. Natural excitement was put together to cause drop-off in the biochemical and mineral nutrients pull sodium and potassium, making the mug sour to taste.IntroductionCoconut (Cocos nucifera L.), belongs to the family of Arecaceae (Palmae), is an important member of the monocotyledons, embed grown through step up the tropic and subtropic regions, is known for versatile uses of its opposite parts. It is part of the daily diet of many people. Oyster white, and translucent coconut bore extracted from unopened inflorescences of coconut palm is reported as a natural and non alcoholic beverage, high in nutritional value and an endorsement thirst quencher. It requires neither mechanical crushing, as in the case of cane, nor remove like that of beet-root. This palm wash up is widely consumed in India, Sri Lanka, Africa, Malaysia, Indonesia, Thailand and Myanmar (Mahanandi, 2006).Coconut sap is considered as nutritious and delicious fuddle with agreeable flavour. The chemical composition of sap varies, depending on various factors, viz. place, age and type of palm, mode and season of its collection. Sap contains a number of minerals and salts and is high in protein. It contains acids like ascorbic acid (one form of vitamin C), nicotinic acid (vitamin B3 and vitamin PP) and riboflavin (Rosengarten and Frederic, (2004)).The method of tapping and collection of sap vary from country to country and also diametric regions within these countries. In India and Srilanka, sap is collected mostly in earthenware pots/bamboo receptacles. The earthen pot/bamboo liberation is connected to the spadix, to be tapped. Lime is coated from inside the po t to encumber excitement of the sap. In this method of collection, the sap quite often gets begrime by trapped insects dust particles. At Central Plantation Crops interrogation Institute (CPCRI), Kasaragod, a simple device has been substantial to collect fresh and hygienic sap from coconut palms. The sap so collected can be used either as ready to serve drink or can be used for the preparation of natural coconut honey, jaggary or coconut sugar without the addition of any chemicals. modified information is useable with regard to the biochmecianl changes in coconut sap upon natural excitement and no reports were availble rough the changes in mineral electrical capacitys in the sap. Thus the objective of the present area was to findout the extend of changes in biochemical and mineral constituents in freshly collected coconut inflourecence sap as well as naturally fermented sap.Materials and methodsCoconut sap collection Fresh, hygienic, unfermented, fresh and clean infloresc ence sap was collected by tapping of unopened spadix of the palm tree Cocus nucifera L. (WCT x GBGD hybrid) in the CPCRI Experimental Farm, using the device developed at CPCRI, Kasaragod, Kerala, India (Patent File No. K.B. Hebbar2425/CHE/2013). Initial pH of the over night collected fresh sap was footmarkd and the one dumb run aground of sap was stored at -20C and another(prenominal) 10 sets of sap samples was kept infra room temperature (25 2C during the study period) to for natural fermentation. Each set of sample was taken at varied time, then pH and other biochemical and mineral constituents were measured. adherence of total sugar and reducing sugar arrive sugar and reducing sugar content in the fermented sap was intrac defer using phenol-sulphuric method (Dubois et al., 1956) and Nelson-Somogyis method (Somogyi, 1952), respectively. In some(prenominal) methods glucose was used as a standard.Estimation of protein and free amino acids Total protein and total free amino acids present in the sap was determined using Lowrys method (Lowry et al., 1951) and ninhydrin method (Moor and Stein, 1948) respectively. Bovine serum albumin and leucine were used as a standard for protein and amino acid estimation, respectively..Estimation of Phenolics Total phenolics content of freshly collected coconut inflorescence sap was measured by FolinCiocalteus phenol reagent (Singleton and Rossi, 1965). Gallic acid in 50% (v/v) methanol solution in concentrations of 10, 20, 30, 40 and 50 mg 100 mL-1 was used as a standard. The content of total phenolics was verbalized as mg gallic acid equivalent (GAE)/100 ml of fresh sample. All samples were examine in triplicate.Estimation of soluble friction matchSoluble phosphorus present in the sap was determined by molybdivanadophosphoric acid method described by Kitsonand Mellon (1944). An aliquot of 10 mL of sap was taken in a 50 mL flask and 10 ml of vanadomolybdate reagent was added and volume was diluted to 50 mL with d oubly distilled water and the color developed was read at 470 nm aft(prenominal) 10 mins. Potassium dihydrogen phosphate was used as a standard.Mineral analysis Mineral content was determined according to official analytic methods (AOAC 1990) using a GBC make Avanta PM atomic absorption mass spectrometer (AAS) equipped with a D2 lamp background correction system using an air-acetylene flame. ratiocinations were carried out in duplicates of individually independent sample of each pH. For the analysis of minerals, coconut sap solutions at different pH were droped through quantitative ashless filter paper and used. The samples were analyzed using AAS calibrated with related minerals in different concentrations for different macro (potassium and magnesium) and micro-minerals (copper, iron and zinc). All the chemicals used in this study were of analytical grade and the standard solutions of minerals for AAS were purchased from Merck, Germany. The detection limits for minerals were 3 g/100 g for K 0.3 g/100 g for Mg 3 g/100 g for Cu 6 g/100 g for Fe and 1 g/100 g for Zn.statistical analyses All statistical analyses were performed using of Statistical Analysis Software system, mutant 9.2 (SAS Institute, Cary, NC, USA) (SAS 2009). Analysis of variance, using PROC GLM was used to determine portentous differences among the fermented sap samples for biochemical and mineral constituents. Simple linear correlational statistics analysis was performed to indicate the measure of correlation and strength of relationship between variables studied.Results and discussionThe coconut inflorescence sap collected using device developed at CPCRI, Kasaragod, Kerala, India was analyzed for biochemical and mineral constituents at initial level immediately subsequently collection, and at different time intervals after allowing for natural fermentation beneath room condition. meaningful differences were observed for all biochemical and mineral constituents, except sodium and po tassium, with respect to natural fermentation (Table 1 and Table 2). bilinear correlation (r) between time, biochemical parameters and minerals studied in coconut inflorescence sap collectible to natural fermentation were given in table 3.Changes in pH The pH of the coconut sap samples fall from 7.57 to 3.95 by the end of 4 hrs delinquent to natural fermentation and observed satisfying negative correlation with time (r = -0.991, at P Changes of total sugar and reducing sugar content At initial time, the total sugar and reducing sugar content in the sap was about 16.78 g and 0.48 g 100 mL-1, respectively. At the end of 4th hr, the total sugar content reduced to 8.9 g 100 mL-1 and reducing sugar content increased to 3.5 g 100 mL-1. Xia et al., (2011) reported that saccharose was the predominant sugar in the fresh sap reducing sugars such as glucose and levulose were in negligible amount in fresh unfermented sap. erstwhile the fermentation starts, the total sugar level was dra stically reduced and at the same time there was a sharp increase in reducing sugar content, which meant that the content of fructose and glucose increased but sucrose decreased. This is due to sucrose being converted into fructose and glucose during initial fermentation. At the same time, the broken down glucose and fructose was utilized by the microorganisms at later corresponds. This may be the reason for the overall reduction in total sugar content from 16.78 g to 8.9 g 100 mL-1. Significant positive correlation between pH and total sugar (r=0.912, at P r= -0.914 and -0.926, respectively, at P Changes of total protein and free amino acids The protein content of the freshly collected coconut sap was about 116.91 mg 100 mL-1, when the fermentation progress, there was a significant increase in the protein content and it reached 839.21 mg 100 mL-1 at the end of 4 hrs, and it was negatively correlated with the free amino acid content. At initial stage the free amino acid content was about 210 mg 100 mL-1 sap. Free amino acid content decreased drastically due to fermentation and reached to 77.76 mg 100 mL-1 sap at pH of about 4.7. Correlation study showed that there was a significant negative correlation between total protein and free amino acids (r= -0.715, at P The phenolic content in fresh sap was about 19.9 mg 100 mL-1. There was a difference in the phenolic content upon fermentation the change in phenolics content didnt showed any trend. Upon fermentation, the content of phenolics starts decreased for up to 90 mins, there after there was a dish state. The results are against the earlier study which showed there was drastic increase in phenolics content due to the release of phenols from polyphenols by the exercise of microbial fermentation (Xia et al., 2011). Earlier studies showed that there was a steady state between hydrolysis of polyphenols and the action of polyphenoloxidase processes that generate and oxidize, respectively, leads to no drastic chan ge in phenolic content (Cruz et al., 2013).The major(ip) biochemical changes occurring in the fermenting sap indicated that a natural fermentation of coconut sap consist of initial lactic acid fermentation, a middle alcoholic fermentation and final acetic acid fermentation. It also appeared that activities brought about by micro-organisms of early phase helped the activities of the micro-organisms in each of the later phases (Atputharajah et al., 1986)Changes in mineral composition by natural fermentation Mineral composition of coconut inflorescence sap and their changes during natural fermentation were given in the table 2. Potassium (177.66 mg/100 mL-1) was the major mineral nutrient present in the fresh sap followed by sodium, which was about 103.92 mg 100 mL-1. In the present study, there was no significant differences were found for the changes in potassium and sodium content in the fresh sap and fermented sap. Soluble phosphorus content in the fresh sap was 2.16 mg 100 mL-1.Th ere was significant differences were found for the soluble phosphorus content in the sap upon fermentation. The soluble phosphorus content was found to increase to 6.41 mg 100 mL-1 at the end of 4th hr due to microbial fermentation, which increases the solubility of the phosphorus. Earlier studies, Lopez et al. (2001) found thatlactic acid bacteria present in sourdough enhanced acidification, leading to increased magnesium and phosphorus solubility.Freshly collected coconut sap was rich in micro-minerals like iron (68.55 g 100 mL-1), copper (32.75 g 100 mL-1) and zinc (15.60 g 100 mL-1). Once the fermentation starts, the level of micro-minerals present in the sap starts declining and the changes was significant. There was a significant negative correlation found between time and all micro-minerals studied (r= -0.948, -0.930 and -0.890 for iron, copper and zinc, respectively, with time). Microorganisms require several(prenominal) micronutrients like manganese, zinc, cobalt, nickel an d copper are available in nature, induct many roles in the cells as a part of enzymes, cofactors that make to contact action of reaction and maintenance of protein structure. This leads to reduction in available micro-mineral circumscribe in the sap during fermentation.ConclusionThe biochemical studies revealed that the freshly collected coconut inflorescence sap was rich in biochemicals such as sugar, protein, free amino acids and mineral nutrients such as sodium, potassium, phosphorus, iron, copper and zinc. Due to natural fermentation there was a drastic change in the above verbalise nutrients except sodium and potassium. In most cases, the natural fermentation reduces the available nutrients in the sap and make the sap sour to taste. Thus, there is a need to find out suitable methods to prevent the natural fermentation of coconut sap without affecting its nutritional quality and make it as a delicious health drink.Table 1. Changes in pH and biochemical composition in coconut inflorescence sap due to fermentationTable 2. Changes in mineral constituents in coconut inflorescence sap due to fermentationTable 3. Linear correlation (r) between the biochemical parameters and minerals studied in coconut inflorescence sap due to natural fermentationTS total sugar RS Reducing sugar AA amino acids* indicates significant at P=0.05Figure 1. Changes in pH, total sugar and reducing sugar contents in coconut inflorescence sap due to fermentation. The results are substitute of trey replicates and values are verbalized as mean SD.Figure 2. Changes in protein and free amino acids content in coconut inflorescence sap due to fermentation. The results are representative of three replicates and values are expressed as mean SD.Figure 3. Changes in sodium, potassium and phosphorus contents in coconut inflorescence sap due to fermentation. The results are representative of three replicates and values are expressed as mean SD.Figure 4. Changes in iron, copper and zinc c ontents in coconut inflorescence sap due to fermentation. The results are representative of three replicates and values are expressed as mean SD.creditReferencesJ Agric Food Chem.2001 May49(5)2657-62.Prolonged fermentation of whole drinking straw sourdough reduces phytate level and increases soluble magnesium.Lopez HW1,Krespine V,Guy C,Messager A,Demigne C,Remesy C.Jaqueline Fontes Moreau Cruz, Paula Bacelar Leite, Sergio Eduardo Soares and Eliete daSilva Bispo. Assessment of the fermentative process from different cocoa cultivars produced in Southern Bahia, Brazil Vol. 12(33), pp. 5218-5225, 14 August, 2013Colorimetric Determination of Phosphorus as Molybdivanadophosphoric AcidR E. Kitson,M G. MellonInd. Eng. Chem. Anal. Ed.,1944,16(6), pp 379383